may 2011 doc id 15609 rev 3 1/37 1 vn5e160as-e single channel high side driver with analog for automotive applications features general ? inrush current active management by power limitation ? very low standby current ? 3.0 v cmos compatible inputs ? optimized electromagnetic emission ? very low electromagnetic susceptibility ? in compliance with the 2002/95/ec european directive ? very low current sense leakage diagnostic functions ? proportional load current sense ? high-precision current sense for wide-range currents ? current sense disable ? off-state open-load detection ? output short to v cc detection ? overload and short to ground (power limitation) indication protections ? undervoltage shutdown ? overvoltage clamp ? load current limitation ? self-limiting of fast thermal transients ? protection against loss of ground and loss of v cc ? overtemperature shutdown with autorestart (thermal shutdown) ? reverse battery protected ? electrostatic discharge protection application all types of resistive, inductive and capacitive loads suitable as led driver description the vn5e160as-e is a single-channel high-side driver manufactured in the st proprietary vipower? m0-5 technology and housed in the tiny so-8 package. the vn5e160as-e is designed to drive 12 v automotive grounded loads delivering protection, diagnostics and easy 3 v and 5 v cmos compatible interface with any microcontroller. the device integrates advanced protective functions such as load current limitation, inrush and overload active management by power limitation, overtemperature shut-off with auto-restart and overvoltage active clamp. a dedicated analog current sense pin is associated with every output channel in order to provide ehnanced diagnostic functions including fast detection of overload and short-circuit to ground through power limitation indication, overtemperature indication, short-circuit to v cc diagnosis and on & off state open-load detection. the current sensing and diagnostic feedback of the whole device can be disabled by pulling the cs_dis pin high to allow sharing of the external sense resistor with other similar devices. max supply voltage v cc 41 v operating voltage range v cc 4.5 v to 28 v max on-state resistance (per ch.) r on 160 m current limitation (typ) i limh 10 a off-state supply current i s 2 a (1) 1. typical value with all loads connected. 6 2 ( " 1 ( $ ' 5 www.st.com
contents vn5e160as-e 2/37 doc id 15609 rev 3 contents 1 block diagram and pin configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 2 electrical specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 2.1 absolute maximum ratings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 2.2 thermal data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 2.3 electrical characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 2.4 waveforms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 2.5 electrical characteristics curves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 3 application information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 3.1 gnd protection network against reverse battery . . . . . . . . . . . . . . . . . . . 24 3.1.1 solution 1: resistor in the ground line (rgnd only) . . . . . . . . . . . . . . . . 24 3.1.2 solution 2: a diode (dgnd) in the ground line . . . . . . . . . . . . . . . . . . . 25 3.2 load dump protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 3.3 mcu i/os protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 3.4 current sense and diagnostic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 3.4.1 short to vcc and off-state open load detection . . . . . . . . . . . . . . . . . 27 3.5 maximum demagnetization energy (vcc = 13.5 v) . . . . . . . . . . . . . . . . . 28 4 package and pcb thermal data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 4.1 so-8 thermal data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 5 package and packing information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 5.1 ecopack ? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 5.2 package mechanical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 5.3 packing information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 6 order codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 7 revision history . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
vn5e160as-e list of tables doc id 15609 rev 3 3/37 list of tables table 1. pin function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 table 2. suggested connections for unused and not connected pins . . . . . . . . . . . . . . . . . . . . . . . . 6 table 3. absolute maximum ratings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 table 4. thermal data. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 table 5. power section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 table 6. switching (v cc = 13 v; tj = 25 c) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 table 7. logic inputs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 table 8. protection and diagnostics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 table 9. current sense (8 v < v cc < 18 v). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 table 10. openload detection (8 v < v cc < 18 v) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 table 11. truth table. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 table 12. electrical transient requirements (part 1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 table 13. electrical transient requirements (part 2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 table 14. electrical transient requirements (part 3) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17 table 15. thermal parameters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 table 16. so-8 mechanical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 table 17. device summary . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 table 18. document revision history . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
list of figures vn5e160as-e 4/37 doc id 15609 rev 3 list of figures figure 1. block diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 figure 2. configuration diagram (top view) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 figure 3. current and voltage conventions (1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 figure 4. current sense delay characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 figure 5. off-state open-load delay timing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 figure 6. switching characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 figure 7. delay response time between rising edge of ouput current and rising edge of current sense (cs enabled) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 figure 8. output voltage drop limitation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 figure 9. i out /i sense vs i out . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 figure 10. maximum current sense ratio drift vs load current (1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 figure 11. normal operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 figure 12. overload or short to gnd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 figure 13. intermittent overload . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 figure 14. off-state open-load with external circuitry . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 9 figure 15. short to v cc . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 figure 16. t j evolution in overload or short to gnd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 figure 17. off-state output current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 figure 18. high-level input current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 figure 19. input voltage clamp. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 figure 20. low-level input voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 figure 21. high-level input voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 figure 22. hysteresis input voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 figure 23. on-state resistance vs. t case . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 figure 24. on-state resistance vs. v cc . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 figure 25. undervoltage shutdown . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 figure 26. turn-on voltage slope . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 figure 27. i limh vs. t case . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 figure 28. turn-off voltage slope . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 figure 29. high-level cs_dis voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 figure 30. cs_dis voltage clamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 figure 31. low-level cs_dis voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 figure 32. application schematic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 figure 33. current sense and diagnostic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 figure 34. maximum turn-off current versus inductance (for each channel) (1) . . . . . . . . . . . . . . . . . . 28 figure 35. so-8 pc board (1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 figure 36. rthj-amb vs pcb copper area in open box free air condition . . . . . . . . . . . . . . . . . . . . . . 29 figure 37. so-8 thermal impedance junction ambient single pulse. . . . . . . . . . . . . . . . . . . . . . . . . . . 30 figure 38. thermal fitting model of an hsd in so-8 (1) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 figure 39. so-8 package dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 figure 40. so-8 tube shipment (no suffix) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 figure 41. so-8 tape and reel shipment (suffix ?tr?) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 4
vn5e160as-e block diagram and pin configuration doc id 15609 rev 3 5/37 1 block diagram and pin configuration figure 1. block diagram table 1. pin function name function v cc battery connection. out power output. gnd ground connection. must be reverse battery protected by an external diode/resistor network. in voltage-controlled input pin with hysteresis, cmos compatible. controls output switch state. cs analog current sense pin, delivers a current proportional to the load current. cs_dis active high cmos compatible pin, to disable the current sense pin. 6 # # # o n t r o l $ i a g n o s t i c , / ' ) # $ 2 ) 6 % 2 6 / . , i m i t a t i o n # u r r e n t , i m i t a t i o n 0 o w e r # l a m p / & |